排煙罩和前端油煙凈化器的清洗方法
Cleaning method for smoke exhaust hood and front end oil fume purifier
油煙進化器排煙罩和前端油煙凈化器一般是設置為一體的。
The smoke exhaust hood and front end smoke purifier are generally integrated.
部件：煙罩包含罩體和罩蓋、防爆燈，前端凈化器包括UV燈、川鐵油網、運水煙罩等。
Components: The smoke hood includes the cover body and cover, explosion-proof light, and the front-end purifier includes UV light, Chuantie oil screen, and water smoke hood.
清洗方法：防爆燈、UV燈可以經常用濕抹布擦干凈，含有擋水板、運水扇、油網、過濾網等前端凈化部件的和排煙罩面板一樣，都需要先將表面油垢鏟干凈，然后放在火堿水里泡，待油泥完全泡除后，再用高壓水槍(清水)洗凈。據經驗證明，80%左右的廚房排煙不暢主要原因是油煙凈化器的內置過濾網不潔堵塞。所以前端凈化器的部件清潔是非常重要的
Cleaning method: Explosion proof lamps and UV lamps can be cleaned frequently with a damp cloth. For front end purification components such as water baffles, water fans, oil screens, and filter screens, just like smoke exhaust hood panels, the surface oil stains need to be removed first, and then soaked in caustic soda water. After the oil stains are completely soaked, they can be cleaned with a high-pressure water gun (water). According to experience, about 80% of kitchens have poor smoke exhaust, which is mainly due to the dirty and clogged built-in filter screen of the oil fume purifier. So it is very important to clean the components of the front-end purifier
二、排煙管道的清洗方法
2、 Cleaning methods for smoke exhaust pipes
排煙管道
Smoke exhaust duct
部件：包含主管道、防火閥、止回閥、調節(jié)閥、消音管道、軟連接、彎頭、三通等。
Components: including main pipeline, fire damper, check valve, regulating valve, silencing pipeline, soft connection, elbow, tee, etc.
清洗方法：油煙管道清洗是排煙口和煙罩相連處，和與煙罩平行的排油煙管道內部，這些地方必須徹底清洗。清洗管道拐彎位置，例如彎頭、三通，必要時在彎頭上方開口。外部油煙管道每隔一個季度清洗一次，不過一個季度只需清潔管道彎頭。
Cleaning method: The key to cleaning the oil fume pipeline is the connection between the smoke exhaust outlet and the smoke hood, as well as the interior of the oil fume pipeline parallel to the smoke hood. These areas must be thoroughly cleaned. Clean the bend position of the pipeline, such as elbows and tees, and open an opening above the elbow if necessary. The external oil fume pipeline should be cleaned every other quarter, but only the pipeline elbows need to be cleaned once a quarter.
三、排煙風機/風柜的清洗方法
3、 Cleaning methods for smoke exhaust fans/cabinets
風柜
Air cabinet
部件：風機包含電機等部件，風柜就是把風機放在柜子里，包含風機和柜體。
Components: The fan includes components such as a motor, and the fan cabinet is where the fan is placed, including the fan and the cabinet body.
清洗方法：清洗時，先拆開電機或拆開電機扇葉，再用鏟刀鏟干凈風機扇葉上的油污及風機里面的油渣，然后用除油劑清洗，洗完后再用清水沖洗干凈。
Cleaning method: When cleaning, first disassemble the motor or motor fan blades, then use a shovel to clean the oil stains on the fan blades and the oil residue inside the fan, and then use a degreaser to clean. After washing, rinse thoroughly with clean water.
風機的內部和外部都要清洗，防止銹蝕。
The interior and exterior of the fan should be cleaned to prevent rusting.
四、后端油煙凈化器的清洗方法
4、 Cleaning method for rear end oil fume purifier
排空油煙凈化器
Drain the oil fume purifier
部件：電機和油煙處理系統(tǒng)（如濾料、靜電處理裝置、離心裝置等）
Components: Motor and oil fume treatment system (such as filter material, electrostatic treatment device, centrifugal device, etc.)
清潔：按照油煙處理裝置的類型進行相應的清潔工作，如更換濾料，清潔靜電處理裝置等。注意：在清洗酒店廚房排煙設備時，帶電的設備必須提前關掉電源。
Cleaning: Perform corresponding cleaning work according to the type of oil fume treatment device, such as replacing filter materials, cleaning electrostatic treatment devices, etc. Attention: When cleaning the smoke exhaust equipment in the hotel kitchen, powered equipment must be turned off in advance.
要想排煙設備使用壽命長，還需要定期做一些日常的保養(yǎng)：如清潔風機、運水扇、分水扇表面污漬，保持管道通暢，保證運水箱內水質潔凈，避免控水箱缺油等等。
To ensure a long service life of smoke exhaust equipment, regular daily maintenance is also necessary, such as cleaning the surface stains of fans, water transport fans, and water distribution fans, maintaining unobstructed pipelines, ensuring clean water quality in the water transport tank, and avoiding oil shortage in the control tank.
一旦發(fā)現任何反常現象，都要找到原因并及時解決。只有這樣才能減少隱患，不耽誤廚房的繁忙工作。
Once any abnormal phenomena are discovered, the cause must be identified and promptly resolved. Only in this way can we reduce hidden dangers and not delay the busy work of the kitchen.
This article is a friendly contribution from the kitchen smoke exhaust hood of Jinan Hotel. For more relevant knowledge, please click on: http://www.euio.com.cn Sincere attitude. We will provide you with comprehensive services. We will gradually contribute more relevant knowledge to everyone. Stay tuned
上一篇：防止鍍鋅風管震動和噪音要注意什么？
下一篇：通風管道主要有哪些作用領域？
